High Priority 97% confidence

No airflow from specific vents or clicking noise behind dashboard

Q: What are the symptoms of No airflow from specific vents or clicking noise behind dashboard in Fiat Bravo II?

No cold air from vents. Weak cabin cooling. A/C does not react to control panel settings. Frost or ice on pipes under the hood

Q: How to fix No airflow from specific vents or clicking noise behind dashboard in Fiat Bravo II?

Replacing cracked flap actuators or lever sets. If the error is positional, it often helps to disassemble the motor and clean the potentiometer with contact spray. Many mechanics dismantle the WHOLE dashboard when replacing engines in Bravo. Meanwhile, this can be done by removing the radio, control panel and glove compartment, using miniature ratchets (e.g. from bit sets) with a lot of patience. Before starting the fight, always clear the actuator error via OBD - in Stilo this is sometimes enough to unlock the 'suspended' control.

in Fiat Bravo II (2001-2014)

Symptoms

No cold air from vents
Weak cabin cooling
A/C does not react to control panel settings
Frost or ice on pipes under the hood

DTC error codes

A/C controller error - sensor/flap position

Verifying license...

Technical diagnosis (Premium)

Recognized technical fault:

Auxiliary controller voltage instability detected

Technical analysis

Detailed analysis of HVAC controller operation parameters, CAN bus data readings, and diagnostic signal waveforms. Purchase PRO access or log in to read the full fault analysis.

Confirmed solution

Complete step-by-step repair procedure including module non-volatile memory reset, sensor calibration, and correct wiring routing. Unlock the full report to see the instruction.

Parts needed

Filters ferrite anti-interference / noise suppressor
Auxiliary starting battery (depending on cell status)

Workshop hacks

Important workshop tips for mechanics regarding bypasses without expensive control module replacement and manufacturer software service bulletins.

TSB / TPI service bulletins

TSB-24-HVAC-01TPI-2068943/2

A/C Technical Specifications

Standard

Refrigerant: R134a Amount (g): 500g Oil: ND8 PAO 68 lub PAG ISO 46 Oil (ml): 130ml

Brava - 1,9 JTD

Refrigerant: R134a Amount (g): 625 – 675g Oil: ND8 PAO 68 lub PAG ISO 46 Oil (ml): 60 – 100ml

Brava - kompresor Denso

Refrigerant: R134a Amount (g): 600 – 650g Oil: ND9 PAO 68 lub PAG ISO 100 Oil (ml): 140 – 180ml

See full specification

Have this problem?

Generate a personalized AI report for your Fiat Bravo II or book a workshop visit.

Generate AI report Schedule visit

No airflow from specific vents or clicking noise behind dashboard

Symptoms

DTC error codes

A/C Technical Specifications

Other problems in Bravo II

Have this problem?